Electrical system (30) • Re: 460 turbo dash lights
No Christmas tree-like connections here, all lights are connected in parallel.But I can send a fully tested replacement board by regular post, that is not very expensive. I will also throw in some...
View ArticleElectrical system (30) • Fuel pump b18ft
Hi can anyone point me in the direction of a fuel pump , bought one from eBay and completely different and doesn't seem to have to power to run anything , thanksStatistics: Posted by POE — Sat Sep 21,...
View ArticleElectrical system (30) • Re: Fuel pump b18ft
Not exactly but I also got the wrong one from getting an equivalent to the Volvo P/N. In the end I just gave the Bosch part number from the body of my old one to MPD (Motor Parts Direct)...
View ArticleElectrical system (30) • Dead battery and a busted earth lead?
Hello everyone,I've been really quiet since my last post but in that time I've had my rear arches redone, some other work and a respray and Bunny is looking glorious. The only problem after all that...
View ArticleElectrical system (30) • Re: Dead battery and a busted earth lead?
Quite simply, replace it.have a read of my post hereIts quicker to simply replace earthing cables than try to replace them.Cut the end off that cable, roll it up and slot it into a new clamp. Add...
View ArticleElectrical system (30) • CEM Mark 1 Pinout
Hello,Does anyone has the pinout/wiring diagram/schematics of a CEM Mark 1 (5 DK 004 696-01) for a 1990 Volvo 480?The electrical diagram that is avaiable to download only have the CEM Mark 3, and I...
View ArticleElectrical system (30) • Re: CEM Mark 1 Pinout
Though I have a MY 1995 480 with a CEM-III, I have a friend with a MY 1989 480 ES who is equally keen with electronics as I am, and he has more or less reverse engineered the CEM-01 pinout and put it...
View ArticleElectrical system (30) • Re: Oil on speed sensor
Hello AlanWhich 480 are we talking about, out of interest?I have just changed the cog on Nilani and also on Nigel's 480 for him - got mine through ebay from a chap in Hungary, and noted Nigel had done...
View ArticleElectrical system (30) • Re: Extreme Speedo Rescue
Loving the work; although I now have instant tool envy and feel I simply must have the same cheapo chinisium tool, even though I’ll probably never use it!So, post tea:Jaster wrote: ↑Sun Dec 08, 2019...
View ArticleElectrical system (30) • It is Alive!
Today, we finally fixed the speedo/odo on my carwe were also able to adjust the brake light switch as wellWhat we had done as our first fix was to take the plug out in the engine bay and solder...
View ArticleElectrical system (30) • Re: It is Alive!
A most excellent (near) start to the new year!I'd add checking the handbrake switch to that list too! Statistics: Posted by jifflemon — Mon Dec 30, 2019 7:05 pm
View ArticleElectrical system (30) • No spark - No start - help or scrap
Hi All After firing up my 480 a few months ago and on the way to my new work shop, it dies mid way and has not been able to start since. I think it's a spark as there's no spark it's turning over its...
View ArticleElectrical system (30) • Re: No spark - No start - help or scrap
if all of the plugs, leads, cap and arm are in good condition i would check the crank sensor, its positioned at the very top of the bellhousing right at the block, can be had on ebay new relatively...
View ArticleElectrical system (30) • Re: Ray le otter, electrical non start
https://youtu.be/zRonaIw9iLYSo far I can confirm it has started without issues, once it is hot will be the point we find out if the alternator is in fact the problem, do you recommend a replacement if...
View ArticleElectrical system (30) • Re: Heater Fan
Anything new on this front? I was checking the voltage on mine today, position 4 no voltage at all and after I checked the connections to the resistor it dropped from 8.something down to 4.something....
View ArticleElectrical system (30) • airbag fault, any ideas?
hello, i have a volvo 480 with the srs light on. the fault code i read was 2-1-2... Steering wheel module: open circuit in wiring was what i could find this code was for.checked the resistance in the...
View ArticleElectrical system (30) • Re: airbag fault, any ideas?
Clockspring?Statistics: Posted by jamescarruthers — Sat Feb 15, 2020 4:41 pm
View ArticleElectrical system (30) • Re: Battery Charging
I sent mine for remanufacture at Just Alternators and Starter Motors. This is all Mike does and he is surprisingly passionate about what he does.www.jasm.co.ukStatistics: Posted by jamescarruthers —...
View ArticleElectrical system (30) • Re: Ray le otter, electrical non start
I have bought back an oscilloscope from work, so I will be able to check over the alternator issue tomorrow following the guide that was posted earlier Will let you guys know results as I find them....
View ArticleElectrical system (30) • black cable cut behind dashboard
Good evening, I'm lucky I had my dashboard reconditioned by robert. I just passed the technical control after 13 years of immobilization. Unfortunately I don't have any speed indication even after...
View Article
More Pages to Explore .....